Product ID:BIA NMMA 2 CYCLE LUBRICANT
MSDS Date:01/14/1991
FSC:9150
NIIN:00F022005
MSDS Number: BMNCN

VALVOLINE OIL CO

3499 DABNEY DR
LEXINGTON, KY 40512

Emergency Phone: (606) 264-7000

Info Phone: (606) 264-7000

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 70-85%

OSHA PEL 5 MG/CUM

ACGIH TLV: 5 MG/CUM

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10-15%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS, TEARING, &
BLURRED VISION. SKIN: IRRITATION, DEFATTING, & DERMATITIS.
INHALATION: NASAL & RESPIRATORY IRRITATION, CNS EFFECTS, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, HEADACHE , UNCONSCIOUSNESS, & DEATH.
INGESTION: MOUTH & GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING,
DIARRHEA, & PNEUMONITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, REDNESS, TEARING, & BLURRED
VISION. SKIN: IRRITATION, DEFATTING, & DERMATITIS. INHALATION:
NASAL & RESPIRATORY IRRITATION, CNS EFFECTS, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE , UNCONSCIOUSNESS, & DEATH. INGESTION:
MOUTH & GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA, &
PNEUMONITIS.

First Aid:SKIN: WASH W/SOAP & WATER. EYE: FLUSH W/PLENTY OF WATER.
INGESTION: DON'T INDUCE VOMITING. GIVE 2 GLASSES WATER. NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. ASPIRATION OF LIQUID INTO LUNGS
MAY CAUSE CHEMICAL PNEUMONITIS WHICH MAY BE FATAL. INHALATION:
REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY, GIVE OXYGEN. IF
BREATHING STOPS, GIVE CPR. KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point:175FF
Lower Limits:1%
Extinguishing Media:REGULAR FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE DEMAN MODE. WATER OR FOAM
MAY CAUSE FROTHING WHICH CAN BE VIOLENT.
Unusual Fire/Explosion Hazard:VAPORS >AIR & MAY TRAVEL ALONG THE
GROUND/MOVED BY VENTILATION & IGNITE BY IGNITION SOURCE DISTANT
FROM HANDLING POINT.

Spill Release Procedures:ELIMINATE IGNITION SOURCES. WEAR PROTECTIVE
EQUIPMENT. STOP SPILL AT SOURCE, DIKE AREA TO PREVENT SPREADING.
PUMP LIQUID TO SALVAGE TANK. TAKE UP REMAINING LIQUID
W/SAND/CLAY/EARTH/FLOOR ABSORBENT/OTH ER ABSORBENT MATERIAL &
SHOVEL INTO CONTAINERS.

Handling and Storage Precautions:USE & STORE ONLY W/ADEQUATE
VENTILATION. DON'T TRANSFER TO UNLABELED CONTAINER. DON'T USE
CUTTING/WELDING TORCH ON THIS CONTAINER, EVEN EMPTY.
Other Precautions:AVOID CONTACT W/EYES & SKIN.

Respiratory Protection:USE NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR
OR NEGATIVE PRESSURE TYPE RESPIRATORS WHEN >TLV.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) MAINTAIN
Protective Gloves:RESISTANT NEOPRENEOR NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES/SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS & OTHER
PROTECTIVE EQUIPMENT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health

Vapor Pres:SEE SUPP.
Vapor Density:>AIR
Spec Gravity:0.861
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BLUE GREEN LIQUID
Percent Volatiles by Volume:10-25%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLARES, PILOT LIGHTS, ELECTRICAL SPARKS,
HEAT, OPEN FLAME, & OTHER IGNITION SOURCES

Waste Disposal Methods:PREVENT RUN-OFF TO SEWERS, STREAMS, OR OTHER
BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.